Feasibility evaluation of two novel systems for the automated preparation and extended storage of DMSO cryopreserved platelets.

BACKGROUND: Manufacturing methods for dimethyl sulfoxide (DMSO)-cryopreserved platelets (CPPs) are manual and labor intensive. Thawing and prepare-for-transfusion steps are in an open system that requires transfusion within 4 h. A fill-and-finish system (CUE) can automate the manufacturing process. A newly configured bag system allows freezing, thawing, and use of resuspension solutions while maintaining the functionally closed system, and extending the post-thaw shelf life beyond 4 h. Our objective is to evaluate the feasibility of the CUE system and the functionally closed bag system. STUDY DESIGN AND METHODS: DMSO was volumetrically added to double-dose apheresis platelets, concentrated, and delivered to a 50- or 500-mL ethylene-vinyl acetate (EVA) bag by the CUE (n = 12). The functionally closed bag system contained 25 mL platelet additive solution 3 (PAS-3) in a 50-mL EVA bag. Control CPP (n = 2) were manually prepared. PAS-3 and CPP were thawed together. CPP were stored up to 98 h (20-24°C) and tested using a standard assay panel. RESULTS: CUE prepared CPP met the design targets: volume, platelet content, and DMSO concentration. CUE CPP P-selectin was high. CD42b, phosphatidylserine (PS) expression, and live cell percentage were favorable compared to controls and favorably maintained over storage. The thrombin generation potency was slightly reduced compared to controls. The 50 mL EVA bag maintained pH for up to 30 h, and the 500 mL EVA bag beyond 76 h. DISCUSSION: The CUE system presents a technically feasible method to prepare CPP. A functionally closed bag system with resuspension solution was successful and can extend the post-thaw storage time of CPP.

Cold stored platelets - Increasing understanding and acceptance.

Platelet transfusions decreased the risk of morbidity and mortality secondary to thrombocytopenia. This therapy not only ameliorates platelet loss in bleeding patients,but also those with acquired dysfunction of platelets. The current standard of practice worldwide is to provide room temperature platelets (RTPs); however, there are many disadvantages to the use of RTPs such that alternative approaches have been explored. One potential approach is the integration and use of cold stored platelets (CSP), which are platelets stored at 1-6 °C, in clinical settings. CSP research studies show equivalent hemostasis and platelet dysfunction restoration compared to RTPs. In addition, publications have demonstrated advantages of CSP such as reduced bacterial contamination and wastage. Despite its benefits, the production of CSP by blood centers (BCs) and uptake and use of CSP by hospitals has remained relatively low. This review highlights the rationale for CSP production and strategies for overcoming the implementation challenges faced by BCs based on a literature review.Experiences of Consortium for Blood Availability members to integrate CSP in their BCs and clinical practices by providing variance applications are reviewed in this paper. Also, demonstrated in this manuscript are the current indications and opportunities for CSP utilization by healthcare providers.

Survey of blood centre readiness regarding removal of DEHP from blood bag sets: The BEST Collaborative Study.

BACKGROUND AND OBJECTIVES: Di(2-ethylhexyl) phthalate (DEHP) must be removed from blood bag sets in Europe by 27 May 2025. DEHP is known to interact with the red blood cell (RBC) membrane, resulting in reduced haemolysis and thus prolonging shelf-life. Current non-DEHP alternatives result in increased haemolysis requiring reconsideration of the RBC shelf-life. Although the immediate impact of eliminating DEHP is to the European community, the non-DEHP movement could affect blood bag set availability globally. The purpose of this survey is to understand blood centre readiness regarding the transition to non-DEHP blood collection and storage systems. MATERIALS AND METHODS: A 24-question on-line survey was completed by members of the Biomedical Excellence for Safer Transfusion Collaborative research network. RESULTS: Responses were obtained from 16 blood collection or processing institutions. A majority of respondents (12/16) indicated that both shelf-life and haemolysis were equally important in selecting non-DEHP blood bag sets. Six respondents would accept a lower RBC product shelf-life compared to current practice. Respondents were not clear on the best non-DEHP vinyl material or RBC storage solution. Three European blood centres indicated they have developed non-DEHP transition plans. One challenge identified regarding the transition to non-DEHP is the extensive validation testing that will be required. CONCLUSION: Blood centres in Europe are concerned with meeting the sunset date for DEHP, considering that limited non-DEHP blood bag and RBC storage solutions are currently available. Banning DEHP in Europe, which may have global ramifications, represents a major challenge not yet fully understood by the transfusion medicine community.

Buffy coat platelets coming to America: Are we ready?

BACKGROUND: Buffy coat (BC) platelets (PLTs) have been used globally for many years. In 2004 Canadian Blood Services (CBS) made the decision to transition from PLT-rich plasma (PRP) to BC PLTs. We reviewed the benefits and manufacture process of BC and the implementation challenges involved. STUDY DESIGN AND METHODS: A literature review was performed in the following areas: BC efficacy, donor population shifts, production and good stewardship of PLTs, logistic considerations with overnight holds, advantages of the overnight hold, the CBS experience, licensure and standards, and changes needed to produce BC PLTs in the United States. The aim was to analyze current practice and identify possible actions for blood centers and hospitals. RESULTS: Implementation of BC would offer an additional source of PLTs to address the growing elderly population and the declining apheresis donor base. Substantial logistic, operational, and financial benefits were seen when CBS transitioned to BC with overnight hold. CONCLUSIONS: Buffy coat blood products are widely used throughout the world. Recent conversion from PRP to BC by CBS showed that conversion can be accomplished with planning, communication, and partnership from all stakeholders. In conclusion, BC PLTs are worth serious consideration in the United States, but regulatory barriers in the United States will need to be addressed.

Platelet storage in more than 90% additive solution containing glucose and bicarbonate has the potential to increase shelf life.

BACKGROUND: Platelet concentrates (PCs) suspended in more than 90% additive solution (AS) are recommended for patients with reactions to platelets stored in plasma. Next-generation AS containing glucose and bicarbonate might enable storage of these PCs for longer than those in current-generation AS, which was therefore evaluated in this study. STUDY DESIGN AND METHODS: Five buffy coat or apheresis-derived PCs were pooled and split into identical units. All units except the control were centrifuged, the plasma removed and replaced with AS (SSP+, PAS-5, or PAS-G), or resuspended in the same plasma and sampled 96 hours after resuspension for analysis. RESULTS: Plasma carryover was less than 10%, total protein less than 1 g/unit, and immunoglobulin A levels lower than 0.1 mg/mL for all PCs in AS. The pH of all the platelets during storage was higher than 6.4. PAS containing glucose maintained superior in vitro platelet function during storage compared with those resuspended in SSP+. Compared with storage in SSP+, storage in PAS-5 or PAS-G resulted in better preservation of platelet adenosine triphosphate and hypotonic shock response, lower annexin V binding, and improved mitochondrial membrane potential. CONCLUSION: Platelets resuspended in PAS-5 and PAS-G maintained in vitro function and metabolism during storage compared with SSP+ platelets. Elevated platelet metabolic activity was noticed in PAS-G, and higher platelet activation was detected with PAS-5. Platelets resuspended in PAS containing glucose has the potential to increase the shelf life of PC in more than 90% AS.

In vitro variables of buffy coat-derived platelet concentrates with residual plasma of down to 10% are stably maintained in new-generation platelet additive solutions.

BACKGROUND: Platelet additive solutions (PASs) facilitate plasma recovery and may reduce the risk of plasma-associated adverse transfusion reactions. Whereas current apheresis techniques are able to produce platelet concentrates (PCs) with reduced residual plasma volumes, it is still technically challenging to prepare PCs with plasma levels less than 20% from whole blood. This study aimed to evaluate the feasibility of producing buffy coat (BC)-derived platelets (PLTs) with as little as 10% residual plasma and to test the ability of PASs to preserve PLT quality under these conditions. STUDY DESIGN AND METHODS: A pool-and-split design was used to evaluate the in vitro quality of semiautomatically prepared BC-derived PCs stored for 7 days in either SSP+ (PAS-IIIM) or Intersol-G (glucose-containing PAS) with 10% to 30% residual plasma in three phases: 1) 30% plasma (SSP+, Intersol-G), 2) 20 and 15% plasma (SSP+, Intersol-G), and 3) 10% plasma (Intersol-G). RESULTS: The different plasma-reduced PAS-PC types were comparable in volume, PLT concentration, and PLT yield and met all regulatory requirements. The in vitro quality variables of PLTs suspended in 20% or less residual plasma were comparable to those of PLTs stored in 30% plasma for both PAS types. PLT activation was slightly higher with SSP+ than with Intersol-G. The quality of PCs suspended in Intersol-G with 10% plasma was well maintained during storage. CONCLUSIONS: Preparation of BC-derived PCs with minimal plasma concentrations as low as 10% is feasible. Late-generation PASs satisfactorily preserve the in vitro quality of such PCs during storage.

Cryopreserved ECP-treated lymphocytes maintain apoptotic response and anti-proliferative effect.

BACKGROUND: The ability to cryopreserve a portion of the cells treated during extracorporeal photopheresis (ECP) would improve therapy logistics, particularly for pediatric patients, by allowing multiple therapeutic doses to be collected from a single apheresis session. However, the effect of cryopreservation on ECP-treated cells is unknown (e.g., ECP-induced lymphocyte apoptosis and inhibition of proliferation). STUDY DESIGN AND METHODS: Mononuclear cell (MNC) apheresis products collected from healthy subjects were ECP-treated using offline methods. Fresh samples of ECP-treated and control cells were placed immediately in culture. The remainder of the cells were frozen in cryovials (n = 8) or cryobags (n = 8) at -80°C. After 1 week of -80°C storage, ECP-treated and control cells were thawed rapidly and samples were placed in culture. Lymphocyte apoptosis was assessed by phosphatidylserine exposure using Annexin V/7-AAD labeling. Lymphocyte proliferation after 3 days culture was measured using the carboxyfluorescein succinimidyl ester labeling technique. RESULTS: On Day 0, apoptosis levels were <5% in fresh ECP-treated and control cells and approximately 20% on thawing of cryopreserved ECP-treated and control cells. Apoptosis levels were comparable between the two cryopreserved groups immediately on thawing, indicating that ECP-treated cells were no more sensitive to the cryopreservation process than control cells. During 72-h culture, apoptosis levels increased to >80% in fresh and cryopreserved ECP-treated cells but remained near constant in both control groups. Inhibition of lymphocyte proliferation was >95% in all ECP-treated cells with no significant difference between fresh and cryopreserved cells (P = 0.12). CONCLUSION: Cryopreservation did not impair the apoptotic response or anti-proliferative effect of ECP-treated lymphocytes, thereby demonstrating early feasibility of this approach.

Separation of in-vitro-derived megakaryocytes and platelets using spinning-membrane filtration.

In-vitro-derived platelets (PLTs) could potentially overcome problems associated with donated PLTs, including contamination and alloimmunization. Although several groups have produced functional PLTs from stem cells in vitro, the challenge of developing this technology to yield transfusable PLT units has yet to be addressed. The asynchronous nature of in vitro PLT generation makes a single harvest point infeasible for collecting PLTs as soon as they are formed. The current standard of performing manual centrifugations to separate PLTs from nucleated cells at multiple points during culture is labor-intensive, imprecise, and difficult to standardize in accordance with current Good Manufacturing Practices (cGMP). In an effort to develop a more effective method, we adapted a commercially-available, spinning-membrane filtration device to separate in-vitro-derived PLTs from nucleated cells and recover immature megakaryocytes (MKs), the precursor cells to PLTs, for continued culture. Processing a mixture of in-vitro-derived MKs and PLTs on the adapted device yielded a pure PLT population and did not induce PLT pre-activation. MKs recovered from the separation process were unaffected with respect to viability and ploidy, and were able to generate PLTs after reseeding in culture. Being able to efficiently harvest in-vitro-derived PLTs brings this technology one step closer to clinical relevance.

The effects of red blood cell preparation method on in vitro markers of red blood cell aging and inflammatory response.

BACKGROUND: Studies are currently under way examining whether the age of stored red blood cells (RBCs) affects clinical outcome in transfusion recipients. The effects of storage duration on the RBC storage lesion are well documented, while fewer studies are available regarding the effect of RBC production method. In this study, we compared in vitro RBC quality variables and markers of inflammatory response in apheresis and whole blood (WB)-derived RBCs, specifically those prepared after an overnight room temperature hold (RTH) of WB. STUDY DESIGN AND METHODS: SAGM RBCs, prepared from WB after overnight RTH (n = 10), were compared to SAGM RBCs prepared using an apheresis device (Alyx, n = 10). As a control, SAGM RBCs were also prepared within 2 hours of WB collection (2-hr WB, n = 10). All RBCs were stored at 4°C for 42 days with weekly assay of in vitro variables, cytokines and/or chemokines, and neutrophil activation after incubation with RBC supernatant. RESULTS: RTH WB RBCs exhibited decreased levels of 2,3-diphosphoglycerate acid (2.3 µmol/g hemoglobin [Hb] ± 2.1 vs. 13.7 ± 1.3 µmol/g Hb) and morphology (160 ± 10 vs. 192 ± 5) on Day 1 and increased hemolysis (0.45 ± 0.21% vs. 0.31 ± 0.09%) and microparticles (6.1 ± 2.8/10(3) RBCs vs. 3.9 ± 1.1/10(3) RBCs) on Day 42 compared to apheresis RBCs. Gro-α and ENA-78 cytokine levels were significantly higher in RTH WB than Alyx RBCs during storage. CD11b expression was highest in neutrophils exposed to supernatant from RTH WB RBCs (p < 0.05). CONCLUSION: RBC preparation method has a meaningful effect on the RBC storage lesion, which should be taken into account in addition to length of storage.

The role of bicarbonate in platelet additive solution for apheresis platelet concentrates stored with low residual plasma.

BACKGROUND: Complex platelet additive solutions (PASs) are required to store platelet (PLT) concentrates with plasma levels below 30%. Previously, apheresis PLTs stored with 5% plasma in acetate- and bicarbonate-containing PAS maintained stable pH and bicarbonate levels during 7-day storage. Due to this observation, the necessity of added bicarbonate in PAS was investigated and whether the concurrent increase in PAS pH after bicarbonate addition had any effect on PLT storage. STUDY DESIGN AND METHODS: Apheresis PLTs were stored in 5% plasma-95% high- or low-pH PAS, with or without bicarbonate (n=10 per arm). Bicarbonate PAS PLTs were paired and nonbicarbonate PAS PLTs were paired (split from same double-dose collection). PLTs were evaluated for in vitro variables on Days 1 and 7 and up to Day 14 if the Day 7 pH was higher than 6.2. RESULTS: PLT pH was maintained above 7.3 to Day 14 in bicarbonate PAS PLTs while pH failures below 6.2 were observed in 4 of 10 and 2 of 10 units on Day 7 in low- and high-pH nonbicarbonate PAS arms, respectively. Day 7 in vitro variables in nonbicarbonate PAS PLTs with pH values of higher than 6.2 were comparable to Day 7 variables in bicarbonate PAS PLTs. The pH of bicarbonate PAS did have a small effect on pH and bicarbonate levels in PLT units, but did not have an effect on functional variables and metabolism. CONCLUSION: Bicarbonate was not required to maintain in vitro PLT function in 5% plasma-95% PAS, but was required as a pH buffer and increased PAS pH did not significantly contribute to this effect.

Exploratory in vitro study of red blood cell storage containers formulated with an alternative plasticizer.

BACKGROUND: The plasticizer di-2-ethylhexyl phthalate (DEHP) is a common component in medical plastics. There is motivation to replace this component; however, DEHP is necessary to prevent excessive hemolysis in stored red blood cells (RBCs). Our objective is to evaluate a candidate replacement plasticizer (Hexamoll, di-isononyl cyclohexane-1,2-dicarboxylic acid [DINCH], BASF Corp.) compared to DEHP in an in vitro feasibility study. We hypothesize that the candidate will provide at least equivalent protection against hemolysis for RBCs stored for 42 days and periodic mixing of RBCs will add additional protection against hemolysis. STUDY DESIGN AND METHODS: Whole blood was collected into citrate-phosphate-dextrose; combined into pools of 2 ABO identical whole blood units; and divided, leukoreduced, centrifuged, and separated into plasma and RBCs. Additive solution was added, and the RBCs were stored for 42 days at 1 to 6°C. In three parts of this study, split pools were paired as DINCH-polyvinyl chloride (PVC) with weekly mixing versus DINCH-PVC with no mixing, DINCH-PVC mixed versus DEHP-PVC no mix, and DINCH-PVC versus DEHP-PVC with neither mixed. A standard panel of in vitro RBC characteristics was determined on Days 0 and 42. RESULTS: Mixing DINCH-PVC weekly improved Day 42 hemolysis (0.36 ± 0.07% vs.0.56 ± 0.15%, p = 0.002), and mixed DINCH-PVC bags were noninferior to unmixed DEHP-PVC bags (p ≤ 0.05). DINCH-PVC bags stored without weekly mixing were inferior to unmixed DEHP-PVC bags for hemolysis on Day 42, although no individual bag exceeded 0.8% hemolysis. CONCLUSION: Periodic mixing of RBCs stored in DINCH-PVC provides additional protection against hemolysis. Unmixed DINCH-PVC bags were inferior to DEHP-PVC bags for prevention of hemolysis, but remain a candidate for replacement DEHP in RBC storage bags.

In vitro variables of apheresis platelets are stably maintained for 7 days with 5% residual plasma in a glucose and bicarbonate salt solution, PAS-5.

BACKGROUND: Platelet additive solutions (PASs) facilitate improved recovery of plasma and may reduce the severity and/or frequency of plasma-associated transfusion reactions. Current apheresis platelet (PLT) PAS products contain approximately 30 to 40% residual plasma. In an effort to further decrease the residual plasma, two in vitro studies were conducted with PLTs suspended in 5% plasma and a reformulated PAS-3, named PAS-5, that contains additional salts, glucose, and bicarbonate. STUDY DESIGN AND METHODS: In Study 1, PLTs suspended in 5% plasma/95% PAS-5 were prepared directly on a separator (Amicus, Fenwal, Inc.) without additional centrifugation or washing. In Study 2, a double unit of hyperconcentrated Amicus PLTs in plasma was collected, divided, and centrifuged to prepare a control unit in 100% plasma and a paired test unit in 5% plasma/95% PAS-5. The in vitro properties of PLTs were assessed in both studies during 7-day storage at 20 to 24°C with continuous agitation. RESULTS: In Study 1, PLT concentration, pH, mean PLT volume (MPV), HCO(3)(-), pCO(2), pO(2), lactate dehydrogenase, and hypotonic shock response (HSR) did not significantly change during storage. By Day 7, glucose levels and morphology scores modestly decreased (17.6 and 14.4%, respectively) and lactate levels modestly increased (to 7.2 mmol/L). In Study 2, MPV, pH, glucose, pO(2), HSR, and morphology were comparable in control and test PLTs during 7-day storage. Glucose consumption and lactate production were significantly less in test versus control PLTs (p≤0.0015). Extent of shape change and %CD62P-positive test PLTs were less than those of controls (p<0.001). CONCLUSION: Apheresis PLTs suspended in 5% plasma/95% PAS-5 maintained in vitro properties during 7-day storage.

Acupressure for treating neurological disorders: a systematic review.

The objective of this review is to assess the clinical evidence for or against acupressure as a treatment for neurological disorders. We searched the literature from 12 databases from their inception to July 2010. We included any type of controlled clinical trial (CCT) in which patients with neurological disorders were treated with acupressure. The methodological quality of all clinical trials was assessed using the Cochrane risk of bias analysis. In total, two randomized clinical trials (RCTs) and four CCTs were included. Four studies (one RCT and three CCTs) compared the effects of acupressure with routine care or no treatment in patients with stroke and showed significant effects of acupressure on improving patient function and symptoms. One RCT, which compared acupressure with sham acupressure and no treatment in patients with headache, also showed that acupressure significantly reduced headache severity and pain. However, all trials were open to methodological limitations and a high risk of bias. In conclusion, current evidence showing that acupressure is an effective treatment for improving function and symptoms in patients with stroke is limited. However, the evidence is insufficient to draw conclusions concerning the effects of acupressure on other neurological disorders. More rigorous studies are warranted.